RH2+ Installation and Operation Manual Includes installation, operation maintenance and troubleshooting information for your RH2
7 | Installation Location Mount on a suitable wall or vertical surface. Do not sit the unit on the floor. Allow clearances required for plumbing and
Installation | 8 Mounting with Keyholes 1 The RH2 humidifier is wall mounted using a keyhole located on the back of the unit cabinetry. 2 Use #8 x
9 | Installation Plumbing Figure 6: Water Supply and Drain Connection Supply water should at 30 to 80 PSIG and be between 150
Installation | 10 Steam Distributor Steam generated by the RH2 Space is blown directly into the space by the integrated blower pack. The RH2 Duct
11 | Installation Figure 7: RH2 Duct Nozzle Distributor Installation Figure 8: RH2 Duct RSD10 Distributor Installation
Installation | 12 Steam Lines and Condensate Return Instructions The following instructions must be followed for installation of steam lines for the
13 | Installation Figure 10: Main Steam Line Requirements MAIN RULES FOR ATMOSPHERIC STEAM LINES Steam lines must not have
Installation | 14 Figure 11: Steam Distributor Above Humidifier (Hose) Figure 12: Steam Distributor Below Humidifie
15 | Installation Figure 13: Steam Distributor Below Humidifier With Obstruction (Hose) Figure 14: Common Steam Lin
Installation | 16 Electrical Figure 15: Primary Power Connection Caution: Wiring to be performed by a licensed Electrician.
Thank you for choosing Nortec. Proprietary Notice This document and the information disclosed herein are proprietary
17 | Installation External Controls Control Wiring Controls are available from Nortec as accessories. If controls were not ordered with humidifier,
Installation | 18 Space Humidification Control Location These instructions apply to the RH2 Space and the RH2 Duct with Remote Blower Pack.
19 | Installation On/Off Control Wiring Figure 18: On/Off Controls Figure 19: Digital On/Off Humidistat
Installation | 20 Modulating Control Wiring Figure 20: Modulating Controls Figure 21: Modulating Control Wiring
21 | Installation Fan Enable Wiring When distributing steam into a duct, there can be a call for humidity when there is no air flow. Either the RH2
Installation | 22 Options and Accessories Remote Blower Pack A remote blower pack is available for the RH2 Duct for applications where steam for humi
23 | Start Up Start Up 24 Installation Check 25 On/Off or Modulating Operation 26 Start Up Procedure 27 Nortec Digital Controls 27 Modula
Start Up | 24 Installation Check Before turning on power to the RH2 inspect the installation to ensure that it was carried out correctly. Refer to R
25 | Start Up On/Off or Modulating Operation From the factory the RH2 is configured to operate as an On/Off humidifier. It will run when 24 VA
Start Up | 26 Start Up Procedure 1 Examine the humidifier and installation for damage and/or improper installation. 2 Ensure the cylinder is prope
Contents 1 Introduction 2 Receiving and Unpacking 3 RH2 Models 4 Options and Accessories 5 Installation 6 Typical RH2 Installat
27 | Start Up Nortec Digital Controls Nortec provides optional On/Off and Modulating digital controls. Figure 26 show the function and meaning of
Start Up | 28 RH2 Pre-Start Up Checklist Unit Serial #: _________________ No. of humidifiers: _______ Tag: _______________ Unit type: _______ ____
29 | Start Up RH2 Start Up Checklist Unit Serial #: _________________ No. of humidifiers: _______ Tag: _______________ Unit type: _______ ________
Start Up | 30
31 | Operation Operation 32 LED Status Lights 32 Selecting a Relative Humidity Setpoint 33 Humidifier Components 34 Description of Component
Operation| 32 LED Status Lights The RH2 user interface includes 2 LED’s which provide information about the humidifier status. Figure 27: LED S
33 | Operation Humidifier Components Figure 28: RH2 Humidifier Components Steam OutletCondensate ReturnFill CupDrain ValveDrain CanalFill Valve
Operation| 34 Description of Components Table 5: Humidifier Components Component Function of Component Blowerpack Disperses steam generated by the hu
35 | Operation Humidifier Schematic Figure 29: Humidifier Schematic
Operation| 36 How the Humidifier Works The RH2 is an atmospheric steam generator that uses heat generated by electrical current flowing between subme
1 | Introduction Introduction CAUTION: Servicing Disconnect main power before any servicing. The plumbing and electrical compartments con
37 | Operation Steam Line The steam line between the cylinder steam outlet and the distributor serves two purposes: it is used as a conduit to transf
Operation| 38 Humidifier Configuration The RH2 is factory configured to operate under most conditions without the need for any changes to its configu
39 | Operation On/Off or Modulating Control (J10) The RH2 output can be controlled by either an On/Off or a modulating humidistat. To set the RH2 to
Operation| 40 Maintenance and Servicing 41 Required Maintenance 41 Cylinder Spent Fault 41 Replacement Cylinder 42 Removing the Cy
41 | Maintenance and Servicing Required Maintenance The RH2 humidifier has been designed to require very little maintenance. Regular maintenance con
Maintenance and Servicing | 42 Removing the Cylinder 1 Drain the existing cylinder by switching the On/Off/Drain switch to the Drain position. Let
43 | Maintenance and Servicing Drain Valve Cleaning Always clean the drain valve before installing a new cylinder. Scale from the spent cylinder may
Maintenance and Servicing | 44 Figure 36: Drain Valve Actuator Assembly Installing the New Cylinder 1 Insert cylinder into drain valve. Tilt cylin
45 | Maintenance and Servicing Extended Shutdown Should it be required to disconnect power to the humidifier for a period of extended shut-down, alwa
Maintenance and Servicing | 46 RH2 Maintenance Checklist Model #: _________________ Serial #: _________________ Tag: ________ Cylinder #: CHE
Introduction | 2 Receiving and Unpacking 1 Check packing slip to ensure ALL material has been delivered. 2 All material shortages are to be rep
47 | Troubleshooting Troubleshooting 48 Organization of Troubleshooting Chapter 48 Troubleshooting Requirements 49 General Troubleshooting
Troubleshooting| 48 Organization of Troubleshooting Chapter The troubleshooting chapter is broken down into 2 sections. General Troubleshooting
49 | Troubleshooting General Troubleshooting The following section provides general guidelines for troubleshooting the RH2 humidifier and auxiliary c
Troubleshooting| 50 Steam Distributors Symptom Cause Corrective Action(s) Distributor spitting out water 1 Distributor not level 1 Use support at
51 | Troubleshooting RH2 Faults The self-diagnostic system built into the RH2 is continually monitoring the operation of the humidifier. When an abn
Troubleshooting| 52 Table 8: Troubleshooting RH2 Faults (Continued) Yellow LED System Detected Cause Corrective Action(s) 2 flashes No Current Fil
53 | Troubleshooting RH2 Wiring Diagram
Spare Parts| 54 Exploded View and Spare Parts List RH2+ Spare Parts The Nortec residential humidifier model should be confirmed. The following s
55 | Spare Parts RH2+ Spare Parts The following spares parts are for RH2+ models only: tNortec Part No. Description 2560953 RH2+ Duct, 10lbs/hr, 1
Spare Parts| 56 RH2+ Spare Parts The following spares parts are for RH2 models only: tNortec Part No. Description 2560953 RH2+ Duct, 10lbs/hr, 120/2
3 | Introduction RH2 Models The RH2 is the most advanced residential steam humidifier available and provides steady and reliable humidification for a
57 | Spare Parts
Warranty | 58 Warranty Nortec Humidity Inc. and/or Nortec Humidity Ltd. (hereinafter collectively referred to as THE COMPANY), warrant for a perio
U.S.A. 1860 Renaissance Blvd Sturtevant, WI 53177 826 Proctor Avenue Ogdensburg, NY 13669 CANADA 2740 Fenton Road Ottawa, Ontario K1T 3T7 TEL: 1
Introduction | 4 Options and Accessories Nortec provides a complete line of options and accessories for every humidification application. The follow
5 | Installation Installation 6 Typical RH2 Installation 7 Location 8 Mounting with Keyholes 9 Plumbing 10 Steam Distributor 12 Stea
Installation | 6 Typical RH2 Installation Figure 3: Typical Humidifier Installation 2
Commentaires sur ces manuels